marble waste powder prtial replacement of sand

Get Price And Support

Experimental Study of Partial Replacement of Fine

b) Waste material from China Clay Industry This material procured from the local china clay products industry was used as partial replacement for river sand. The properties of the material investigated are presented in table 2. The size of the material used is 4.75 mm and down size. 2 Coarse aggregate

Get price

Performance of Using Waste Glass Powder In Concrete

Performance of Using Waste Glass Powder In Concrete As Replacement Of Cement Gunalaan Vasudevan1, waste glass powder from their Potsdam facility alone. Most of this waste material is being land filled at a aggregate and sand contents were 1080 and780 kg/m3, respectively. After a number of trials, adjusting the

Get price

Walnut Shell for Partial Replacement of Fine Aggregate in

Jul 04, 2017Abstract. The huge need of natural resources and the raising pollution problems from agro wastes disposal have become the top most important factors behind using agro waste in con

Get price

Experimental Study on Use of Sugar Cane Bagasse Ash in

Therefore it might possible to use sugarcane bagasse ash (SCBA) as cement replacement material to improve quality and reduce the cost of construction materials such as mortar, concrete pavers, concrete roof tiles and soil cement interlocking block etc.

Get price

Comments of case study sand replacement with quarry dust

Replacement Of Sand With Quarry Dust greenrevolution. Therefore, this study recommends that if partial replacement of sand with quarry dust upto 10% in M35 grade of concrete is done, the effective waste management can contribute towards saving of our environment. case study sand replacement with quarry dust_Ore Processing.

Get price

Waste Materials in Concrete Technology

Recyclable materials in concrete technology sustainability and durability G. Moriconi products that are suitable for partial replacement of portland cement, aggregate, and drinking water . enhanced when concrete-rubble powder, that is the

Get price

Development of Lightweight Sand-Cement Bricks

utilising quarry dust (QD), rice husk (RH) and kenaf powder (KP), which can be considered as waste to overcome the shortage of sand. The research involved the preparation of three mix proportions, which are 12.5, 13.0 and 13.5 with 10%, 15%, 20%, 30% and 40% of

Get price

effect of granulated slag as sand replacement in concrete

Use Of Blast Furnace Slag Sand In Concrete As A An Experimental Investigation on Utilization of Waste. Waste Foundry Sand and Granulated Blast Furnace Slag as Partial Replacement to Sand in Fly Ash replacement of sand with Granulated Blast Furnace Slag at.

Get price

Effects of Wood Ash and Waste Glass Powder on Properties

Rai, B. and Naushad, K. (2011) Marble Powder Concrete. International Journal of Engineering Sciences Research-IJESR, 3, 68. 3. Akshay, S.C. and Naghathan, S.J. (2009) Experimental Investigation of Waste Quarry Stone Dust as the Partial Replacement of Sand in Concrete Production.

Get price

Abstract Index Terms

of using waste glass powder as partial replacement of fine aggregates up to 30% by weight for particle size of range 0-1.18mm. Glass is widely used in our lives through manufactured products such as sheet glass, bottles, glassware, and vacuum tubing.

Get price

Strength and Durability Properties of Granite Powder

of using granite powder as replacement of sand and partial replacement of cement with fly ash, silica fume, slag and superplasticiser in concrete. The percentageof granite powder added by weight was 0, 25, 50, 75 and 100 as a replacement of sand used in concrete and cement was replaced with 7.5% silica fume, 10% fly ash, 10% slag and

Get price

Zainelabdin Khalid Zainelabdin Elfaki Mining House

This paper of using of marble waste in concrete making aims to show the influence of partial replacement of cement with marble waste on the workability and compressive strength of concrete. Three replacement percentages of 10%, 20% and 30% were used with different curing times of 7, 14and 28 days.

Get price

What are the advantages of using quarry dust as fine

May 23, 2017From the experimental study, it is concluded that the quarry dust can be used as a replacement for fine aggregate. It is found that 40% replacement of sand by quarry dust gives maximum result in strength compared to normal concrete and then decreases from 50%.

Get price

International Journal of Engineering Trends and

structures. Glass powder finer than 600 is reported to have pozzolanic behaviour. An attempt is made to investigate the possibility of using the waste glass powder as the partial replacement of ordinary Portland cement in concrete. Concrete with replacement of cement by waste glass powder such as 5%,

Get price

An Experimental Study on Strength of Concrete by

have to replace fully or partially the constituent materials of concrete by using waste materials. replacement. Fine aggregate used was M-sand from local quarry. Crumb Rubber used in the study to replace fine aggregate. S. Sarankokila, K. Sargunan 2014. Experimental Investigation of Egg Shell Powder as Partial Replacement with Cement

Get price

EXPERIMENTAL STUDY ON PROPERTIES OF CONCRETE BY PARTIAL

Using of sawdust ash in concrete is an interesting possibility for economy on waste disposal sites and conservation of natural resources .This paper examines the possibility of using sawdust ash as replacement in fine aggregate for a new concrete. Natural sand was

Get price

REPLACEMENT OF NATURAL SAND IN CONCRETE BY

ground waste glass as partial natural sand replacement in concrete. The results showed a very significant compressive strength improvement with the increasing of percentage replacement of natural sand by ground waste glass. A higher compressive strength was obtained with a lower expansion verified by the bar tests.

Get price

Experimental Investigation of Waste Glass Powder and

the partial replacement of the glass powder and fly ash combination can be a good substitute for cement. Apart from the strength, the new type of concrete helps to recycle the waste glass powder and fly ash thereby protecting the environment and reduce the construction cost. Keywords waste glass powder and fly ash, concrete, strength, replacement

Get price

Performance Evaluation of Properties of High Performance

Abstract The purpose of the research is to evaluate the properties of High Performance Mortars (HPMs) produced from Metakaolin (MK) and Waste Marble Dust (WMD) as a partial substitution to Ordinary Portland Cement (OPC) in binary and ternary cementitious mixtures. For this scope, the water/binder ratio utilised to prepare the mortar was 0.30 with a binder content of 640 kg/m 3 totally and a

Get price

Studies on Glass Powder as Partial Replacement of

Studies on Glass Powder as Partial Replacement of Cement in Concrete Production The interest of the construction community in using waste or recycled materials in concrete is increasing because of the emphasis placed on sustainable construction, the waste glass from in and around the small shops is packed as a waste and disposed as landfill.

Get price
Published in Journal of Engineering Science and Technology Review 2013Authors Tomas U Ganiron

Effect of Using Glass Powder in Concrete rroij

Waste glass is one materials when ground to a very fine powder shows pozzolanic properties which can be used as a partial replacement for cement in concrete. In this paper, an attempt has been made to find out the strength of concrete containing waste glass powder as a partial replacement

Get price

RECLAIMING FOUNDRY WASTE GREEN SAND AND

sand system or as a replacement for new sand in the core room. Foundry cores made from 60% reclaimed sand, 40% new sand, and 1.1% phenolic urethane binder, yielded a 120 psi tensile strength, well above the 70-80 psi tensile strength that is often specified at this foundry.

Get price

The Effect of Micronized Waste Marble Powder as Partial

This article was focused on the influence of the micronized waste marble powder on mechanical properties of cement pastes. Resulting blended cement was composed of Portland cement CEM I 42.5 R and micronized marble powder with different percentage amounts (0 wt. %, 5 wt. %, 10 wt. % and 15 wt. %). Testing was carried at prismatic samples of dimension 40 40 160 mm.

Get price

STUDY ON STRENGTH AND DURABILITY OF CONCRETE

sand) are so far and/or will be superior to any other material in making concrete, their availability is continuously being depleted due to the intentional overexploitation through out the Globe. Hence, partial or full replacement of fine aggregates by the other

Get price

Glass Powder A Partial Replacement for Cement?

Due to the successful implementation of these waste materials into regular concrete there is increased desire to find new post-consumer materials which can be used as a partial replacement for cement. The experimental work presented in this research looks at the use of

Get price

sand replacement by crusher dust in concrete pdf

replacement of sand by crusher dust in concrete pdf () STUDY ON EFFECTIVE REPLACEMENT OF NATURAL SAND Feb 19, 2015 concrete by partial or full replacement of natural sand by crusher dust, in t his study two basic mixers (M- 20 and M-25 grade concrete) were selected for natural sand to achieve the replacement .

Get price

Experimental Investigation of Partial Replacement of

Experimental Investigation of Partial Replacement of Cement with Glass Powder and Eggshell Powder Ash in Concrete in eggshell ash powder is a fowl waste by means of chemical Civil Eng Res J 5(3) CERJ.MS.ID.555662 (2018) 001 available sand and coarse aggregates were in this experiment . Specific gravity of coarse aggregate is 2.74.

Get price

A STUDY ON PARTIAL REPLACEMENT OF CEMENT

replacement of natural sand with steel slag sand, which is yet another waste material lying in steel plants across Karnataka. Objectives 1. To study the fresh properties and to assess the compressive strength of SCC using egg shell powder (ESP), a waste material, as partial replacement for cement. 2.

Get price

Effect of Waste Glass Powder in Concrete by Partial

powder in various concrete grades by partial replacement of cement. Use of milled waste glass in concrete as partial replacement of cement could be an important step toward development of eco-friendly and techno-economical systems. In this study OPC was replaced partially with waste glass powder at 5%, 10%, 15% and 20% by weight of the cement

Get price

Influence of Granite Powder as Partial Replacement of

the picture to reduce the solid waste and to reduce the scarcity of natural aggregates. Crushed waste tiles and Granite powder are used as a replacement to the coarse aggregates and fine aggregate. The combustion of waste crushed tiles were replaced in place of coarse aggregates by 10%, 20%, 30% and Granite powder

Get price